Evaluating optical hazards from plasma arc cutting.

The Health Hazard Evaluation Program of the National Institute for Occupational Safety and Health evaluated a steel building materials manufacturer. The employer requested the evaluation because of concerns about optical radiation hazards from a plasma arc cutting system and the need to clarify eye protection requirements for plasma operators, other employees, and visitors. The strength of the ultraviolet radiation, visible radiation (light), and infrared radiation generated by the plasma arc cutter was measured at various distances from the source and at different operating amperages. Investigators also observed employees performing the plasma arc cutting. Optical radiation above safe levels for the unprotected eyes in the ultraviolet-C, ultraviolet-B, and visible light ranges were found during plasma arc cutting. In contrast, infrared and ultraviolet-A radiation levels during plasma arc cutting were similar to background levels. The highest non-ionizing radiation exposures occurred when no welding curtains were used. A plasma arc welding curtain in place did not eliminate optical radiation hazards to the plasma arc operator or to nearby employees. In most instances, the measured intensities for visible light, UV-C, and UV-B resulted in welding shade lens numbers that were lower than those stipulated in the OSHA Filter Lenses for Protection Against Radiant Energy table in 29 CFR 1910.133(a)(5). [1] Investigators recommended using a welding curtain that enclosed the plasma arc, posting optical radiation warning signs in the plasma arc cutter area, installing audible or visual warning cues when the plasma arc cutter was operating, and using welding shades that covered the plasma arc cutter operator's face to protect skin from ultraviolet radiation hazards.

Coccidioides exposure and coccidioidomycosis among prison employees, California, United States.

Responding to a request by corrections agency management, we investigated coccidioidomycosis in prison employees in central California, a coccidioidomycosis-endemic area. We identified 103 cases of coccidioidomycosis that occurred over 4.5 years. As a result, we recommended training and other steps to reduce dust exposure among employees and thus potential exposure to Coccidioides.

Acute symptoms associated with asphalt fume exposure among road pavers.

BACKGROUND: Although asphalt fume is a recognized irritant, previous studies of acute symptoms during asphalt paving have produced inconsistent results. Between 1994 and 1997, the National Institute for Occupational Safety and Health (NIOSH) evaluated workers at seven sites in six states. METHODS: NIOSH (a) measured exposures of asphalt paving workers to total (TP) and benzene-soluble particulate (BSP), polycyclic aromatic compounds, and other substances; (b) administered symptom questionnaires pre-shift, every 2 hr during the shift, and post-shift to asphalt exposed and nonexposed workers; and (c) measured peak expiratory flow rate (PEFR) of asphalt paving workers when they completed a symptom questionnaire. RESULTS: Full-shift time-weighted average exposures to TP and BSP ranged from 0.01 to 1.30 mg/m(3) and 0.01 to 0.82 mg/m(3), respectively. Most BSP concentrations were <0.50 mg/m(3). Asphalt workers had a higher occurrence rate of throat irritation than nonexposed workers [13% vs. 4%, odds ratio (OR) = 4.0, 95% confidence interval (CI): 1.2-13]. TP, as a continuous variable, was associated with eye (OR = 1.34, 95% CI: 1.12-1.60) and throat (OR = 1.40, 95% CI: 1.06-1.85) symptoms. With TP dichotomous at 0.5 mg/m(3), the ORs and 95% CIs for eye and throat symptoms were 7.5 (1.1-50) and 15 (2.3-103), respectively. BSP, dichotomous at 0.3 mg/m(3), was associated with irritant (eye, nose, or throat) symptoms (OR = 11, 95% CI: 1.5-84). One worker, a smoker, had PEFR-defined bronchial lability, which did not coincide with respiratory symptoms. CONCLUSIONS: Irritant symptoms were associated with TP and BSP concentrations at or below 0.5 mg/m(3).

Responding to a bioterrorist attack: environmental investigation of anthrax in New Jersey.

A bioterrorism attack using the United States postal system to deliver a hazardous biological agent to specific targets created multiple environmental and occupational exposure risks along the path of the anthrax-containing letters. On October 18, 2001, a suspected case of cutaneous anthrax was confirmed in a postal worker from the Trenton Processing and Distribution Center where at least four suspect letters were postmarked. Over the next three weeks, a team of investigators collected samples at 57 workplaces in New Jersey as part of a comprehensive environmental investigation to assess anthrax contamination as a result of this bioterrorist attack. A total of 1369 samples were collected with positive sample results found in two mail processing and distribution centers, six municipal post offices, and one private company. This large-scale epidemiological and public health investigation conducted by state and federal agencies included environmental evaluations utilizing general industrial hygiene principles. Issues of sampling strategy, methods, agency cooperation and communication, and site assessment coordination are discussed.

Epidemiologic investigations of bioterrorism-related anthrax, New Jersey, 2001.

At least four Bacillus anthracis-containing envelopes destined for New York City and Washington, D.C. were processed at the Trenton Processing and Distribution Center (PDC) on September 18 and October 9, 2001. When cutaneous anthrax was confirmed in a Trenton postal worker, the PDC was closed. Four cutaneous and two inhalational anthrax cases were identified. Five patients were hospitalized; none died. Four were PDC employees; the others handled or received mail processed there. Onset dates occurred in two clusters following envelope processing at the PDC. The attack rate among the 170 employees present when the B. anthracis-containing letters were sorted on October 9 was 1.2%. Of 137 PDC environmental samples, 57 (42%) were positive. Five (10%) of 50 local post offices each yielded one positive sample. Cutaneous or inhalational anthrax developed in four postal employees at a facility where B. anthracis-containing letters were processed. Cross-contaminated mail or equipment was the likely source of infection in two other case-patients with cutaneous anthrax.

Environmental sampling for spores of Bacillus anthracis.

On November 11, 2001, following the bioterrorism-related anthrax attacks, the U.S. Postal Service collected samples at the Southern Connecticut Processing and Distribution Center; all samples were negative for Bacillus anthracis. After a patient in Connecticut died from inhalational anthrax on November 19, the center was sampled again on November 21 and 25 by using dry and wet swabs. All samples were again negative for B. anthracis. On November 28, guided by information from epidemiologic investigation, we sampled the site extensively with wet wipes and surface vacuum sock samples (using HEPA vacuum). Of 212 samples, 6 (3%) were positive, including one from a highly contaminated sorter. Subsequently B. anthracis was also detected in mail-sorting bins used for the patient's carrier route. These results suggest cross-contaminated mail as a possible source of anthrax for the inhalational anthrax patient in Connecticut. In future such investigations, extensive sampling guided by epidemiologic data is imperative.

Lead exposure from conventional and cottage lead smelting in Jamaica

A survey was conducted to determine the distribution and determinants of environmental and blood lead levels near a conventional and several cottage lead smelters and to assess the relationship between environmental and blood lead levels in a tropical developing-country setting. Fifty-eight households were studied in the Red Pond community, the site of the established smelter and several backyard smelters, and 21 households were studied in the adjacent, upwind Ebony Vale community in Saint Catherine Parish, Jamaica. Households were investigated, using questionnaires, soil and housedust lead measurements, and blood lead (PbB) measurements from 372 residents. Soil lead levels in Red Pond exceeded 500 parts per million (ppm) at 24 percent of household (maximum--18,600 ppm), compared to 0 percent in Ebony Vale (maximum 150 ppm). Geometric mean PbB levels >25 micrograms per deciliter (ug/dL), was more than twice that Ebony Vale in all age groups (p<0.0005). Within Red Pond, proximity to backyard smelters and to the conventional smelter were independent predictors of soil lead (p<0.05). Soil lead was the strongest predictors of PbB among Red Pond subjects under 12 years of age. The blood lead--Soil lead relationship in children differed from that reported in developed countries; blood lead levels were higher than expected for the household-specific soil lead levels that were observed. These data indicate that cottage lead smelters, like conventional ones, are a hazard for nearby residents and that children exposed to lead contamination in tropical, developing countries may be at higher risk for developing elevated blood levels than similarly-exposed children in developed countries (AU)

Lead poisoning among household members exposed to lead-acid battery repair shops in Kingston, Jamaica

To investigate the risk of lead poisoning among household members exposed to 'backyard' battery repair shops (BBRS) in Kingston, Jamaica, environmental and blood lead (PbB) were measured at 24 households (112 individuals) with a BBRS worker or located at a BBRS premises and at 18 neighbourhood control households (74 individuals). Elevated PbB (greater than or equal to 25 micrograms per decilitre [micrograms/dl]) was common among subjects of all ages living at BBRS premises, especially among children less than age 12, 43 percent of whom had PbB greater than 70 micrograms/dl. Potentially hazardous soil and house dust lead levels were also common at BBRS premises, where 84 percent of yards had soil lead levels above 500 parts per million (geometric mean 3388 parts per million [ppm] at BBRS premises households with a BBRS worker). Geometric mean blood and environmental lead levels were significantly lower at control households, where less than 10 percent of subjects in all age groups had elevated PbB (maximum 33 microgram/dl). Sharing a premises with a BBRS was a stronger determinant of household blood lead and environmental contamination than was the presence of a BBRS worker in a household. Blood lead levels were associated with soil and house dust lead levels in all age groups. We conclude that small battery repair shops, which have also been described in other developing countries, create a high lead poisoning risk for nearby residents (AU)

Lead exposure among lead-acid battery workers in Jamaica

To assess lead exposure in the Jamaican lead-acid battery industry, we surveyed three battery manufacturers (including 46 production workers) and 10 battery repair shops (including 23 battery repair workers). Engineering controls and respiratory protection were judged to be inadequate at battery manufacturers and battery repair shops. At manufacturers, 38 of 42 air samples for lead exceeded a work-shift time-weighted average concentration of 0.050 mg/m3 (range 0.030-5.3 mg/m3), and nine samples exceeded 0.050 mg/m3 (range 0.003-0.066 mg/m3). Repair shop workers, however, had higher blood lead levels than manufacturing workers (65 percent vs. 28 percent with blood lead levels above 60 micrograms/dl, respectively). Manufacturing workers had a higher prevalence of safe hygienic practices and a recent interval of minimal production had occurred at one of the battery manufacturers. Workers with blood lead levels above 60 micrograms/dl tended to have higher prevalences of most symptoms of lead toxicity than did workers with lower blood lead levels, but this finding was not consistent or statistically significant. The relationship between zinc protoporphyrin concentrations and increasing blood lead concentrations was consistent with that described among workers in developed countries. The high risk of lead toxicity among Jamaican battery workers is consistent with studies of battery workers in other developing countries. (AU)